Advertisem*nts
Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford F150 (1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004).
Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system from overloading. If electrical parts in your vehicle are not working, the system may have been overloaded and blown a fuse or tripped a circuit breaker. Before you replace or repair any electrical parts, check the appropriate fuses or circuit breakers.
To check a fuse, look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Notice
- Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged.
- Always disconnect the battery before servicing high current fuses.
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Never replace a broken fuse with anything other than a new fuse. Use always an intact fuse of the same color.
- If a fuse blows again contact a qualified service center.
See Also
Ford F-150 2013 Fuse BoxPassenger Compartment Fuse Box Diagram
The fuse panel is located behind the lid below and to the left of the steering wheel by the brake pedal. Pull the panel cover outward to access the fuses. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
| № | A | Protected Circuits |
|---|---|---|
| 1 | 15 | Audio |
| 2 | 5 | Powertrain Control Module (PCM), Cluster |
| 3 | 20 | Cigar lighter, Data link connector |
| 4 | 5 | 2000-2004:Power mirror switch, Mirror turn signal relays |
| 15 | 1997-1999:Autolamp Module, Remote Entry Module, Mirrors | |
| 5 | 15 | Speed control module, Reverse lamp, Climate mode switch, Daytime Running Lamps (DRL) relay, Digital Transmission Range (DTR) sensor (2001-2004), AC Clutch Relay (1997-1999) |
| 6 | 5 | Cluster, Brake shift interlock solenoid, GEM, Rear Air Suspension Module (1997-1999) |
| 7 | — | Not used |
| 8 | 5 | Radio, Remote entry module, GEM, In-vehicle entertainment system (SuperCrew only) |
| 9 | — | Not used |
| 10 | — | Not used |
| 11 | 30 | Front washer pump relay, Wiper run/park relay, Wiper HI/LO relay, Windshield wiper motor |
| 12 | — | Not used |
| 13 | 20 | Stop lamp switch (Lamps), Turn/Hazard flasher, Speed Control Module (1997-2000) |
| 14 | 15 | Battery saver relay, Interior lamp relay, Accessory Delay Relay (Power Windows) (1997-2000) |
| 15 | 5 | Stop lamp switch (speed control, brake shift interlock, ABS (1997-2000), PCM Module Inputs (1997-2000)), GEM, Rear Anti-lock Brake System (RABS) module |
| 16 | 20 | Headlamps (hi beams), Cluster (hi beam indicator) |
| 17 | — | Not used |
| 18 | 5 | Instrument illumination (dimmer switch power) |
| 19 | — | Not used |
| 20 | 5 | Audio, GEM, Powertrain Control Module (PCM), Transmission range sensor |
| 21 | 15 | Clutch switch, Starter relay, I/P fuse 20, Digital Transmission Range (DTR) Sensor (2001-2004) |
| 22 | 10 | Air bag module, Passenger air bag deactivation module |
| 23 | 10 | Trailer tow battery Charge relay, Turn/Hazard flasher, 4x4 solenoids, 4x4 relays, Overhead console, 4-Wheel Anti-lock Brake System (4WABS) module, EC mirror, Heated seats |
| 24 | 10 | 2001-2004:Function selector switch assembly |
| 1997-1999:Climate Mode Switch (Blower Relay) | ||
| 25 | 10 | 2003-2004:Heated mirrors |
| 5 | 1997-1999:4 Wheel Anti-Lock Brake System (4WABS) Module | |
| 26 | 10 | Right-hand low beam headlamp |
| 27 | 5 | Foglamp relay and foglamp indicator, Main light switch (upstream) (2001-2004) |
| 28 | 10 | Left-hand low beam headlamp |
| 29 | 5 | Autolamp module, Transmission overdrive control switch, Central security module (2001-2004), Beltminder (2001-2004) |
| 30 | 30 | Passive Anti-theft transceiver, Cluster, Ignition coils, PCM relay, Coil on plugs (2001-2004), Radio noise capacitor (2001-2004), ECC diode (2001-2004) |
| 31 | — | Not used |
| R1 | Interior lamp relay | |
| R2 | Battery saver relay | |
| R3 | Not used | |
| R4 | One-touch down window relay | |
| R5 | Accessory delay relay | |
Advertisem*nts
Engine Compartment Fuse Box Diagram
The power distribution box is located in the engine compartment and contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
| № | A | Protected Circuits |
|---|---|---|
| 1 | 20 | Power point |
| 2 | 30 | Powertrain Control Module (PCM) |
| 3 | 30 | Main light switch, Headlamp relay, Multifunction switch |
| 4 | 20 | Console power point (Harley Davidson only) |
| 15 | 1997-1999:Air Suspension | |
| 5 | 20 | Trailer tow back-up/park lamps |
| 6 | 15 | Main light switch, Park lamp relay |
| 7 | 20 | Horn |
| 8 | 15 | Power door locks, Central Security Module (CSM) (2001-2004), Lock relays (not used on SuperCrew) (2001-2004) |
| 9 | 15 | Daytime Running Lamps (DRL), Fog lamps |
| 10 | 20 | Fuel pump |
| 11 | 20 | Alternator field |
| 12 | 20 | 2000-2004:Rear auxiliary power point |
| 13 | 15 | 2000-2004:A/C clutch |
| 14 | — | Not used |
| 15 | 10 | 2001-2004:Running board lamps |
| 16 | 15 | 2003-2004:Bi-fuel injector module, fuel selector switch and alternative fuel injectors (Bi-fuel vehicles only) |
| 17 | — | Not used |
| 18 | 15 | PCM, Fuel injectors, Fuel pump relay, Mass air flow sensor |
| 19 | 10 | Trailer/Camper adapter (right stop/tum lamp) |
| 20 | 10 | Trailer/Camper adapter (left stop/turn lamp) |
| 21 | — | Not used |
| 22 | — | Not used |
| 23 | 15 | HEGO sensor, Automatic transmission (2000-2004), Canister Vent (1997-2000), Powertrain Control Module (1997-1999), CMS Sensor (2000) |
| 24 | 15 | 1997-1999:Powertrain Control Module, Automatic Transmission, CMS Sensor |
| 101 | 30 | Trailer tow battery charge |
| 102 | 50/20 | Four-wheel Anti-lock Brake System (4WABS) module/Rear-wheel Anti-lock Brake System (RABS) module, Ignition switch |
| 103 | 50 | Central junction box |
| 104 | 30 | 4x4 shift motor &clutch |
| 105 | 40 | Climate control front blower |
| 106 | 20 | 2000-2004:Intercooler pump (supercharged engine only) |
| 107 | — | Not used |
| 108 | 30 | Trailer tow electric brake |
| 109 | 50 | 1997-1999:Air Suspension Compressor |
| 110 | 30 | 2001-2004:Accessory delay relay (Not used on SuperCrew) |
| 1997-2000:Power Windows | ||
| 111 | 40 | Ignition switch battery feed (start and run circuits) |
| 112 | 30 | Drivers power seat, Adjustable pedal switch (2000-2004) |
| 113 | 40 | Ignition switch battery feed (run and accessory circuits) |
| 114 | — | Not used |
| 115 | 20 | 2000-2004:Power door locks (SuperCrew only) |
| 116 | 40 | 2003-2004:Heated backlight |
| 117 | — | Not used |
| 118 | 30 | 2001-2004:Heated seats |
| 601 | 2000-2004:Power windows, Moonroof (SuperCrew only) | |
| 602 | Not used | |
| 201 | Trailer tow park lamp relay | |
| 202 | Front wiper run/park relay | |
| 203 | Trailer tow backup lamp relay | |
| 204 | A/C clutch relay | |
| 205 | Horn relay | |
| 206 | Fog lamp relay | |
| 207 | Front washer pump relay | |
| 208 | 2000-2004:Intercooler pump relay (supercharged engine only) | |
| 209 | Front wiper HI/LO relay | |
| 301 | Fuel pump relay | |
| 302 | Trailer tow battery charge relay | |
| 303 | 2003-2004:Heated backlight relay (SuperCrew only) | |
| 1997-1999:Rear Air Suspension Relay | ||
| 304 | Powertrain Control Module Relay | |
| 305 | 2000-2004:Fuel pump HI/LO relay (supercharged engine only) | |
| 306 | 2000-2004:Inertia switch relay (supercharged engine only) | |
| 401 | Not used | |
| 501 | Powertrain Control Module Diode | |
| 502 | A/C compressor diode | |
| 503 | Not used | |
Advertisem*nts
