Make and Model > Ford, Lincoln, Mercury > F-Series Trucks > 2010 F150 Fuse Box Diagram: Exploring the Fuse Boxes
2010 F150 Fuse Box Diagram — Find the correct fuse for the circuit you’re working on for the
The 2010 F150 fuse box diagram is similar to the 2009 F150 and represents a major change over the 2008 and previous model years. You’ll find two two fuse boxes in your 2010 F150: an under-hood fuse box called the Battery Junction Box/Power Distribution Box and a passenger compartment fuse box called the Smart Junction Box/Passenger Compartment Fuse Panel.
To learn more about automotive fuses, see this article
To learn how to check a fuse visually or without removing it, see this article
Find the most commonly replaced fuses and bulbs here
The fuse box diagram and table below show all 71 fuses and all the relays. But most DIYers are looking for fuses and relays for the lights, power ports, and the blower motor. I’ve listed the most commonly checked/replaced fuses here to save time. I’ve also listed the most commonly replaced bulbs. A blown fuse or bulb are the two most common reasons for lighting issues
• Backup Light: Fuse #39 (BJB) 10A, Bulb #3156 flareside, #921 styleside
• Blower Motor: Fuse #51 30A (BJB)
• Headlight Low Beam Passenger Side: Fuse #8 10A (SJB), Bulb #H13 (dual filament for high and low beams)
• Headlight Low Beam Driver’s Side: Fuse #7 10A (SJB), Bulb #H13 (dual filament for high and low beams)
• Headlights High Beam: Fuse #23 15A (SJB), Bulb #H13 (dual filament for high and low beams)
• Horn: Fuse #24 20A (SJB)
• Parking lamps: Fuse #22 15A (SJB), Front park turn bulb #3157A (amber)
• Power Ports: Rear: Fuse #72 20A (BJB), Instrument Panel: Fuse #65 20A (BJB), Cigar Lighter #22 20A (BJB), Center Console #66 20A (BJB), Overhead #18 10A
• Stop and Turn lights: Fuse #6 20A (SJB), Bulb #4057 Styleside, #3057 Flareside
2010 F150 Fuse Box Diagram for the Power Distribution Box/Battery Junction Box
The power distribution box is located in the engine compartment. It contains high-current fuses that protect your vehicle’s main electrical systems from overloads. It also contains relays that switch power on and off to high-current devices.
How to find your fuse and the devices served by that fuse
There are 83 fuse/relay slots in the Power Distribution Box. The table shows only 10 to speed up load time. Here’s how to find the fuse and circuit you want.
1) Change the number of entries showing (in the Show Entries Box) to 100 and scroll the list.
2) Enter the name of the component you’re searching for in the Search box.
3) Use the Next/Previous buttons at the bottom of the table
Fuse Number | Amperage | Circuits Protected |
---|---|---|
1 | — | Powertrain control module (PCM) power relay |
2 | — | Starter relay |
3 | — | Blower motor relay |
4 | — | Heated backlite relay |
5 | — | Electric fan relay (high speed) |
6 | — | Trailer tow park lamp relay |
7 | — | Upfitter 1 relay |
8 | — | Fuel pump |
9 | — | Trailer tow battery charger |
10 | — | Upfitter 2 relay |
11 | 30 | Power running board motors |
12 | 40 | Cooling fan low speed relay |
13 | 30 | Starter relay |
14 | 30 | Seat control switch, passenger side front |
15 | 40 | Cooling fan high speed relay |
16 | — | Not used |
17 | 30 | Trailer Brake Control (TBC) module |
18 | 30 | Upfitter 1 |
19 | 30 | Upfitter 2 |
20 | 20 | Transfer Case Control Module (TCCM) |
21 | 30 | Trailer tow battery charge relay |
22 | 20 | Cigar lighter, front |
23 | — | A/C clutch relay |
24 | — | Upfitter 4 relay |
25 | — | Heated mirror relay |
26 | 10 | PCM power relay, Evaporative emission (EVAP) canister vent solenoid, 6R80 transmission |
27 | 20 | Fuel pump relay |
28 | 10 | Upfitter relay 4 |
29 | 10 | Integrated Wheel End (IWE) solenoid |
30 | 10 | A/C clutch |
31 | 20 | Trailer tow park lamp relay |
32 | 40 | Rear window defrost relay |
33 | — | Not used |
34 | 40 | PCM power relay |
35 | — | Not used |
36 | 30 | Anti-lock Brake System (ABS) module |
37 | — | Trailer tow left hand stop/turn relay |
38 | — | Trailer tow right hand stop/turn relay |
39 | — | Back up lamps relay |
40 | — | Electric fan relay |
41 | 15 | Heated mirror relay |
42 | — | Not used |
43 | 20 | Reversing lamp relay |
44 | 15 | Upfitter relay 3 |
45 | 20 | Left and right trailer tow turn relays |
46 | 15 | Brake Pedal Position (BPP) switch |
47 | 60 | Anti-lock Brake System (ABS) module, RSC module |
48 | — | Not used |
49 | 30 | Windshield wiper motor, washer pump |
50 | — | Not used |
51 | 40 | Blower motor relay |
52 | — | Not used |
53 | 5 | Powertrain Control Module (PCM), 6R80 transmission |
54 | 5 | Anti-lock Brake System (ABS) module, Transfer Case Control Module (TCCM) Digital Transmission Range (DTR) sensor Trailer tow battery charge relay |
55 | 5 | Auto-dimming interior mirror unit, Rear view camera display mirror |
56 | — | Not used |
57 | — | Not used |
58 | 15 | Trailer tow connector - Reverse lamps |
59 | — | Not used |
60 | — | Not used |
61 | — | Not used |
62 | — | Not used |
63 | 25 | Cooling fan relay |
64 | 30 | Audio Digital Signal Processing (DSP) module |
65 | 20 | Power point, instrument panel |
66 | 20 | Power point, console 1 - with floor shifter |
67 | — | Not used |
68 | ||
69 | ||
70 | — | Not used |
71 | — | Not used |
72 | 20 | Power point, console 1 - with column shifter Power point, console 2 - with floor shifter |
73 | — | Not used |
74 | 30 | Seat control switch, driver side front - without memory Driver Seat Module (DSM) - with memory |
75 | 15 | Powertrain Control Module (PCM) |
76 | 20 | Brake Pedal Position (BPP) switch, Mass Air Flow/Intake Air Temperature (MAF/IAT) sensor, Variable Camshaft Timing (VCT) solenoids, Heated oxygen sensors (HO2Ss), Evaporative emission (EVAP) canister purge valve, EGR system module, Intake Manifold Runner Control (IMRC) |
77 | 10 | Cooling fan relays, A/C clutch relay. Positive Crankshaft Ventilation (PCV) heated fitting, Floor shifter, Overdrive cancel switch |
78 | 15 | Coil on Plugs (COPs). Ignition transformer capacitors |
79 | 10 | Heated oxygen sensors (HO2Ss). 4R75 transmission |
80 | 5 | Steering wheel switches - illumination |
81 | — | Not used |
82 | 10 | Trailer Brake Control (TBC) module |
83 | — | Not used |
84 | — | Not used |
85 | — | Not used |
A note about fuses, battery power and keep alive memory
If you disconnect the battery or remove the PCM fuses from the fuse box, the PCM will lose its adaptive memory and baseline throttle body position. You can avoid this by providing backup power using a jumper pack and an inexpensive OBDII cable. See this article for more information on providing backup power to prevent the loss of adaptive memory. Or, you can perform a throttle body relearn procedure and then drive the vehicle so it can relearn the new adaptive memory settings. See this article for instructions on how to perform a 2010 F150 throttle body relearn procedure.
2010 F150 Fuse Box Diagram for the Instrument Panel Fuse Box/Smart Junction Box
The fuse panel for the 2010 F150 is located under the dash on the right-hand side of the instrument panel. To remove the trim panel pull the panel toward you. Then swing it out and away
from the side and remove it.
To reinstall it, line up the tabs with the grooves on the panel, then push it closed.
Fuse Number | Amperage | Circuits Protected |
---|---|---|
1 | 30 | Roof opening panel module, Moon Roof |
2 | 15 | Not used (spare) |
3 | 15 | Not used (spare) |
4 | 30 | Not used (spare) |
5 | 10 | Keyless entry keypad, Floor shifter, Brake shift interlock |
6 | 20 | Front park/turn lamps, Rear park/stop/turn lamps, Exterior rear view mirrors, Left and right trailer tow turn relays |
7 | 10 | Low beam headlamps (left) |
8 | 10 | Low beam headlamps (right) |
9 | 15 | Front and rear interior/map lamps assemblies, Front dome lamp, High mounted stoplamp |
10 | 15 | Exterior rear view mirrors, Backlighting |
11 | 10 | Global Positioning System Module (GPSM) - with SYNC |
12 | 7.5 | Exterior rear view mirror switch Driver Seat Module (DSM) - with memory |
13 | 5 | Accessory Protocol Interface Module (APIM), SYNC |
14 | 10 | Interior Lighting Control Module (ILCM) |
15 | 10 | HVAC module, EMTC - with manual a/c, HVAC module, DATC - with automatic a/c |
16 | 15 | Ignition switch feed |
17 | 20 | Door lock actuators |
18 | 20 | Seat control switch, driver side front |
19 | 25 | Not used (spare) |
20 | 15 | Data Link Connector (DLC), Adjustable pedal switch |
21 | 15 | Headlamp switch, Fog lamps |
22 | 15 | Front park/turn lamps, Front side lamps, Rear park/stop/turn lamps, License plate lamps, Front and rear marker lamps, High mounted stoplamp, Trailer tow parking lamp relay |
23 | 15 | Left and right headlamps - high beam |
24 | 20 | Horn, Horn switch |
25 | 10 | Front and rear interior/map lamps assemblies, Vanity mirror lamps, Tool link antenna module (in-dash computer with tool link), Front dome lamp |
26 | 10 | Instrument Cluster (IC), Key release interlock actuator, Front display interface module (FDIM) - without navigation, Front controls interface module (FCIM), Ignition switch |
27 | 20 | Not used |
28 | 5 | Audio Control Module (ACM) (without in-dash computer), In-dash computer |
29 | 5 | Instrument panel cluster |
30 | 5 | Passenger airbag disable indicator |
31 | 10 | Restraints Control Module (RCM) |
32 | 10 | Heated seat module, Electronic compass |
33 | 10 | Trailer Brake Control (TBC) module, Telematics module |
34 | 5 | Mode Select Switch (MSS), Off-road mode switch, Hill descent control switch, Electronic locking differential indicator |
35 | 10 | Parking Aid Module (PAM), Left rear heated seat module |
36 | 5 | Passive anti-theft system transceiver |
37 | 10 | Upfitter relay coils, switch |
38 | 20 | Subwoofer amplifier |
39 | 20 | Audio Control Module (ACM) (without in-dash computer), Front Display Interface Module (FDIM) - with navigation In-dash computer |
40 | 20 | Rear heated seats module |
41 | 15 | Audio Control Module (ACM), Door lock switches, Auto-dimming interior mirror unit, Rear view camera display mirror |
42 | 10 | Not used (spare) |
43 | 10 | Rain sensor module, Rear view camera, Rear window defrost relay, Heated mirror relay |
44 | 10 | Not used (spare) |
45 | 10 | Blower motor relay, Windshield wiper motor logic |
46 | 7.5 | Occupant classification sensor (OCS) |
47 | 30A Circuit Breaker | Master window adjust switch, Passenger side window adjust switch, Overhead console switch assembly, Roof opening panel modulet |
48 | 15 | Delayed accessory relay (Feeds fuse 41 and circuit breaker 47) |
Tips to diagnose electrical issues on your 2010 F150
If your power windows don’t work
• The power windows don’t use fuses. They get power from a 30A circuit breaker #47 in the smart junction box.
If your blower motor doesn’t work
The blower motor gets its power from the blower motor relay #3 in the battery junction/power distribution box.
If the circuit you’re working on contains a relay
• A simple way to test a relay is to swap in a similarly shaped relay and see if the component works.
• If that doesn’t work, remove the relay and test for power to the relay control coil and contacts using a multimeter. For more information on relay testing, see this article.
©, 2018 Rick Muscoplat
Categories
- F-Series Trucks
- Ford
- Fuses
Tags
- 2010 Ford F150 Fuse diagram
- 2010 Ford F150 Fuses